Engine Will Not Start: Troubleshooting Steps

Administrator

Administrator
Staff member
Joined
Mar 26, 2024
Messages
61
Reaction score
7
6th Gen 4Runner Won't Start - What to check and What To Consider First

(Reference: 2025 Owner’s Manual, pg. 604)
Link to Owners Manual: https://trail4runner.com/wp-content/uploads/2025/03/2025-4runner-owners-manual.pdf

If your 4Runner won't start even when following the proper procedures, use these quick checks to help narrow down the issue.

Common Causes​

  • Out of Fuel – Make sure the tank isn’t empty
  • Flooded Engine – Try again using correct startup steps (pg. 218)
  • Immobilizer Issue – May require dealer assistance (pg. 70)
  • Dead Battery – See Jump Starting section (pg. 608)
  • Loose Battery Terminals – Inspect and tighten (pg. 535)
  • Blown Fuse or Weak Key Battery – Can disrupt ignition system
  • Disconnected Battery – Reconnect and attempt to start again

Temporary Emergency Starting Procedure​

If nothing else works, Toyota allows a one-time emergency start method:
  1. Set the parking brake
  2. Shift to “P”
  3. Turn engine switch to ACC
  4. Press and hold the engine switch for ~15 seconds while holding the brake pedal
If the vehicle starts using this method, it may indicate a deeper issue—get it checked at your dealer as soon as possible.

2025 4Runner Engine Will Not Start Troubleshooting Diagram​

See page 604/605 for the flowchart and emergency restart procedure.

2025-4runner-engine-will-not-start-troubleshooting.jpg
 

Featured

Official Pricing will be released this fall...
Ok guys, here is a quick look at the new 6th...
I think this is the 2025 4Runner Platinum in...

Recent

Hey guys, We had a couple of customers come in looking to solve the 12V accessory wiring...
Hey all! Underground Sport Premium. 20' Nitto Ridge Grappler tires. Pretty much everything is...
I know the pro and trailhunter have wider fenders, but are the Off-road trims wider than the...
Yes they sure do. I have these laying around from my old fourth GEN and I decided to give them a...
After mocking up a few other wraps and livery concepts, I started to play around with the Turbo...
Has anyone encountered this yet with your new 4Runner? It’s starting to get humid here in FL and...
When at the New York Autoshow, I had the unique opportunity to have both a 4R Limited and LC250...
Seeing if anyone with other models have pre drilled threads in their frame for aftermarket rock...
Back at it with some wrap inspiration on the 6th Gen 4Runner. We have everything from multi-cam...
Take a look at some of these livery mockups inspired by the 1st Gen 4Runner Turbo graphics with...
Anyone install the readylift or peak performance leveling kits yet? I'm trying to decide on...

Similar

Back
Top